Use of construction renovation and demolition waste in

Use of construction renovation and demolition waste in

So experiments were carried out in the laboratory to scrutinize a concrete made of partial replacement of coarse aggregate with construction and demolition waste materials like ceramic tiles waste

Get Price
(PDF) The Use of Ceramic Tiles Waste in Concrete as

(PDF) The Use of Ceramic Tiles Waste in Concrete as

Show full abstract aggregate replacement scheme in concrete is investigated with three different waste ceramic tile materials in replacement ratios including 20 25 35 50 65 75 80

Get Price
Effect of Partial Replacement of Fine and Coarse Aggregate

Effect of Partial Replacement of Fine and Coarse Aggregate

replacement of sand or partial replacement of coarse aggregate but in this research both the components has been used parallel at equal percentage. Ceramic Waste . The amount of ceramic tile waste on earth is enough for use as a coarse and fine aggregate in concrete. Ceramic tile is produced from natural materials sintered at high temperatures

Get Price
EXPERIMENTAL INVESTIGATION ON CONCRETE WITH

EXPERIMENTAL INVESTIGATION ON CONCRETE WITH

Hemanth Kumar et al studied of the suitability of waste crushed tiles in the concrete mix. In this experimental study different mixes are casted waste crushed tiles are used to partially replace the coarse aggregate by 10 and 20 and tiles powder is used to partially replace the fine aggregate

Get Price
Experimental Investigation on Ceramic Tile Wastes as

Experimental Investigation on Ceramic Tile Wastes as

incorporating tile waste as coarse aggregate and tile waste concrete using acrylic polymer. Test on durability were conducted on maximum strength obtained in concrete mix of particular percentage of ceramic waste tile. Key Words Ceramic tile waste acrylic polymer coarse aggregates Cement strength of concrete. 1. INTRODUCTION

Get Price
Use of RECYCLED AGGREGATES In CONCRETE- A Paradigm Shift

Use of RECYCLED AGGREGATES In CONCRETE- A Paradigm Shift

The use of recycled aggregates in concrete prove to be a valuable building materials in technical environment and economical respect Recycled aggregate posses relatively lower bulk density crushing and impact values and higher water absorption as compared to natural aggregate.

Get Price
STRENGTH BEHAVIOR OF CONCRETE BY PARTIAL

STRENGTH BEHAVIOR OF CONCRETE BY PARTIAL

concrete materials were decided to reuse industrial waste such as Copper Slag as fine aggregate replacement in range of 10 20 30 by weight of sand and the Ceramic Waste (Tile Shabath Stone waste) as Coarse Aggregate replacement in 10 20 25 and 20 30 35 by weight of coarse aggregate. Totally 180-cubes

Get Price
Strength and Behavior of Self Compacting Concrete with

Strength and Behavior of Self Compacting Concrete with

ceramic. Therefore the aim of this research is to use the ceramic waste tiles in SCC as a partial replacement of coarse aggregate and investigate the effect of high-temperature (room temperature to 400˚C) on the strengths of this type of concrete. The experimental program consists of casting and testing of 180 specimens (cubes 100 x100x100

Get Price
Reuse of Ceramic Waste as Aggregate in Concrete

Reuse of Ceramic Waste as Aggregate in Concrete

The use of these tile aggregates as partial replacement in coarse aggregate in concrete has positive effect on the environment and obtaining lower costs since the tile aggregates are easy to obtain. Their cost is cheaper than the natural aggregates. The ceramic tile aggregate are partial replaced with coarse

Get Price
AN EXPERIMENTAL INVESTIGATION ON CONCRETE BY

AN EXPERIMENTAL INVESTIGATION ON CONCRETE BY

The copper slag is used as partial replacement for fine aggregate in the range of 20 40 and 60 by weight of sand and its optimum level is to be found. The ceramic waste tiles is used as partial replacement for coarse aggregate ranging from 10 20 30 with optimum slag content as constant.

Get Price
Experimental study for the use of ceramic waste as partial

Experimental study for the use of ceramic waste as partial

Aug 08 2019 · Crushed waste ceramic tiles crushed waste ceramic tile powder and Granite powder are used as a replacement to the coarse aggregates and fine aggregate. The ceramic waste crushed tiles were partially replaced in place of coarse aggregates by 10 20 30 40 .

Get Price
Use of waste material as aggregatesNotes Engineering

Use of waste material as aggregatesNotes Engineering

Notes Engineering Civil Engineering Use of waste material as aggregates. Use of Waste Materials As a replacement of Coarse Aggregate in Concrete Mix. Share on Facebook. Use of waste material as aggregates in civil engineering applications is beneficial

Get Price
CERAMIC TILES WASTE AS COARSE AGGREGATES PARTIAL

CERAMIC TILES WASTE AS COARSE AGGREGATES PARTIAL

aggregates replacement towards compressive strength of concrete. iii) To determine the water absorption of ceramic aggregate concrete containing various content of ceramic tile as partial coarse aggregates replacement material. 1.4 SCOPE OF STUDY Ceramic tile waste use in this research was taken from old site factory The

Get Price
Utilization of Construction Waste Tiles as a Replacement

Utilization of Construction Waste Tiles as a Replacement

Ceramic wastes are found to be suitable for usage as substitution for fine and coarse aggregates in concrete production. This study is an investigation into the utilization of waste tiles as partial replacement for fine and coarse aggregates in concrete.

Get Price
(PDF) Utilization of crushed tile as aggregate in concrete

(PDF) Utilization of crushed tile as aggregate in concrete

Utilization of waste clay tiles as a partial replacement of fine or coarse aggregate in concrete is one of the alternative to the aggregate Inoue et al. (2007) .

Get Price
Experimental Investigation on Ceramic Tile Wastes as

Experimental Investigation on Ceramic Tile Wastes as

incorporating tile waste as coarse aggregate and tile waste concrete using acrylic polymer. Test on durability were conducted on maximum strength obtained in concrete mix of particular percentage of ceramic waste tile. Key Words Ceramic tile waste acrylic polymer coarse aggregates Cement strength of concrete. 1. INTRODUCTION

Get Price
VALLUR PRAKASAM(Dt).

VALLUR PRAKASAM(Dt).

Crushed waste ceramic tiles crushed waste ceramic tile powder and Granite powder are used as a replacement to the coarse aggregates and fine aggregate. The ceramicwaste crushed tiles were partially replaced in place of coarse aggregates by 10 20 30 40 and 50 .Granite powder and ceramic tile powder were

Get Price
CERAMIC TILES WASTE AS COARSE AGGREGATES PARTIAL

CERAMIC TILES WASTE AS COARSE AGGREGATES PARTIAL

aggregates replacement towards compressive strength of concrete. iii) To determine the water absorption of ceramic aggregate concrete containing various content of ceramic tile as partial coarse aggregates replacement material. 1.4 SCOPE OF STUDY Ceramic tile waste use in this research was taken from old site factory The

Get Price
PROPERTIES OF CONCRETE WITH CRUSHED WASTE CERAMIC

PROPERTIES OF CONCRETE WITH CRUSHED WASTE CERAMIC

waste wall and floor tiles as a replacement for natural coarse aggregate. The waste tile aggregate was crushed and graded to have the same size of natural coarse aggregate. The study was done by replacing 0 50 and 100 of natural coarse aggregate with waste tile aggregates.

Get Price
(PDF) Utilization of crushed tile as aggregate in concrete

(PDF) Utilization of crushed tile as aggregate in concrete

Utilization of waste clay tiles as a partial replacement of fine or coarse aggregate in concrete is one of the alternative to the aggregate Inoue et al. (2007) .

Get Price
Utilization Of Waste Ceramic Tiles As Coarse Aggregate In

Utilization Of Waste Ceramic Tiles As Coarse Aggregate In

in the National Building Code of India the use of slaga waste from steel industry fly asha waste from thermal power plants crushed over-burnt bricks and tileswaste from clay brick and tile industry in plain cement concrete as an alternative to sand/natural aggregate subject

Get Price
Steel chip and porcelain ceramic wastes used as

Steel chip and porcelain ceramic wastes used as

For this purpose concrete specimens were cast using two types of concrete mixes 1) concrete mixes with 1 1.25 and 1.5 volume ratios of steel chips alone and 2) concrete mixes with the same amounts of steel chips plus 25 50 and 100 weight ratios of porcelain tile waste used as replacement for coarse aggregate.

Get Price
Effect of Crushed Tiles Aggregate and Oil Palm Additive on

Effect of Crushed Tiles Aggregate and Oil Palm Additive on

The use of waste material as aggregates in civil engineering applications is beneficial and is becoming increasingly desirable because it reduces the environmental impact and economic cost of quarrying operations processing and transportation. Thus this study focused on establishing the effect of crushed tile and oil palm fibre additive on the compressive and flexural strength of concrete.

Author S. O. Osuji S. A. Adegbemileke K. Agbonze Get Price
Partial Replacement of Coarse Aggregate with Demolished

Partial Replacement of Coarse Aggregate with Demolished

of recycled concrete up to 30 coarse aggregate replacement (C. A. R.) by demolished waste at the end of 28 d has been found to be comparable to the conventional concrete. 3. "Use of Building Demolished Waste as Course Aggregate in Use of recycled aggregate in concrete can be useful for Porous Concrete" IJRET International

Get Price
International Journal for Research in Applied Science

International Journal for Research in Applied Science

Partial Replacement of Coarse Aggregate by Waste Ceramic Tile in Concrete M. Sekar Civil and Structural Engineering SCSVMV University Abstract The main focus of this research is to study the strength of concrete with ceramic waste as coarse aggregate. Increased

Get Price
Effect of Crushed Tiles Aggregate and Oil Palm Additive on

Effect of Crushed Tiles Aggregate and Oil Palm Additive on

The use of waste material as aggregates in civil engineering applications is beneficial and is becoming increasingly desirable because it reduces the environmental impact and economic cost of quarrying operations processing and transportation. Thus this study focused on establishing the effect of crushed tile and oil palm fibre additive on the compressive and flexural strength of concrete.

Get Price
Plastic Aggregates in ConcretePlaggregateYouTube

Plastic Aggregates in ConcretePlaggregateYouTube

Click to view on Bing2 29

Dec 06 2016 · EZ-CRETE a manufacturer of precast concrete products is investigating the feasibility of using waste plastic to replace traditional rock or expanded shale aggregate.

Author EZ-CRETE Get Price
Effect of Crushed Waste Ceramic Tiles (CWCT) as Partial

Effect of Crushed Waste Ceramic Tiles (CWCT) as Partial

The crushed waste ceramic tiles were substituted in place of fine aggregates in the following percentages (0 20 25 30 35 and 40 ) in the concrete mix. The water /cement ratio used was 0.6. The compressive strength of the concrete cast with the above partial replacement of fine aggregate were determined after 7 and 28 days age of curing.

Get Price
Effect of Crushed Tiles Aggregate and Oil Palm Additive on

Effect of Crushed Tiles Aggregate and Oil Palm Additive on

replacement of ceramic tile aggregate with natural coarse aggregate. Swathi et al. 22 partially replaced fine aggregate with copper slag at 20 40 and 60 and coarse aggregate with waste ceramic tiles at 10 20 and 30 . A grade 40 concrete was used. It was observed that the compressive strength increased by 7.59N/mm2 at a combination 40

Get Price
EXPERIMENTAL STUDY ON PARTIAL REPLACEMENT OF

EXPERIMENTAL STUDY ON PARTIAL REPLACEMENT OF

partial replacement of waste ceramic tiles used as an alternative coarse aggregate and it is compared with controlled cubes. Aggregates are replaced by waste ceramic tiles for various percentages 25 30 35 and the strength is checked. It is expected that the strength of cubes for replacements will not

Get Price
AN EXPERIMENTAL INVESTIGATION ON CONCRETE BY

AN EXPERIMENTAL INVESTIGATION ON CONCRETE BY

percentage of replacement. The copper slag is used as partial replacement for fine aggregate in the range of 20 40 and 60 by weight of sand and its optimum level is to be found. The ceramic waste tiles is used as partial replacement for coarse aggregate ranging from 10 20 30 with optimum slag content as constant.

Get Price
(PDF) Experimental Investigation on Ceramic Tile Wastes as

(PDF) Experimental Investigation on Ceramic Tile Wastes as

https //irjet/archives/V4/i10/IRJET-V4I1075.pdf

Get Price
PROPERTIES OF CONCRETE WITH CRUSHED WASTE CERAMIC

PROPERTIES OF CONCRETE WITH CRUSHED WASTE CERAMIC

waste wall and floor tiles as a replacement for natural coarse aggregate. The waste tile aggregate was crushed and graded to have the same size of natural coarse aggregate. The study was done by replacing 0 50 and 100 of natural coarse aggregate with waste tile aggregates.

Get Price
(PDF) Experimental Investigation on Ceramic Tile Wastes as

(PDF) Experimental Investigation on Ceramic Tile Wastes as

https //irjet/archives/V4/i10/IRJET-V4I1075.pdf

Get Price
STRENGTH BEHAVIOR OF CONCRETE BY PARTIAL

STRENGTH BEHAVIOR OF CONCRETE BY PARTIAL

concrete materials were decided to reuse industrial waste such as Copper Slag as fine aggregate replacement in range of 10 20 30 by weight of sand and the Ceramic Waste (Tile Shabath Stone waste) as Coarse Aggregate replacement in 10 20 25 and 20 30 35 by weight of coarse aggregate. Totally 180-cubes

Get Price
Experimental Investigation on Geopolymer Concrete by

Experimental Investigation on Geopolymer Concrete by

making use of geopolymer concrete to be cured under normal ambient conditions for ease of the construction. In addition to this the use of ceramic waste aggregate as possible partial substitute for conventional coarse aggregate in geopolymer concrete was also analyzed. Fly ash based geopolymer

Get Price